Common Fridge Problems We Fix
❄️ Fridge Not Cooling or Cooling Less
This is the most common fridge problem. The reason is almost always a gas leak — either from the evaporator (the chamber inside that creates cold) or the condenser (the warm side on the back or bottom of the fridge).
Here is exactly how we find and fix it —
✅ Step 1 — Pressure Test on the Chamber
We cut the gas valve and apply 200 PSI pressure to the evaporator chamber. We seal both sides and leave it for 24 hours. If pressure holds — the chamber is fine. If it drops — there is a leak inside.
✅ Step 2 — Chamber Repair with 100% Copper Pipe
If the evaporator chamber is leaking, we rebuild it from scratch using 100% copper pipe — the most durable material for fridge chambers. After rebuilding, we seal it properly with foam sheet for maximum insulation.
✅ Step 3 — Condenser Check
If the chamber is fine but the fridge still isn't cooling, we check the condenser (the warm coil on the outside). If damaged, we replace it with a new one.
🔌 Fridge Suddenly Stops Working
If your fridge runs for a while and then shuts off — or doesn't start at all — the problem is usually the relay or overload protector connected to the compressor.
✅ We check both parts first
✅ If faulty, we replace them immediately — this is a quick and affordable fix
✅ If the relay and overload are fine, we check the compressor itself
✅ If the compressor is damaged, we replace it — with gas charge included
🌡️ Too Much Ice Building Up — Thermostat Problem
If your fridge never stops running and ice keeps building up higher and higher inside — the thermostat is likely faulty. The thermostat controls when the fridge turns off and on automatically. When it fails, the fridge runs non-stop and ice accumulates abnormally.
✅ We test the thermostat and replace it if needed
✅ After replacement, your fridge will cycle normally again
🛢️ Normal Section Not Cooling — Oil Flush & Capillary Cleaning
Sometimes the deep freezer section works fine but the normal fridge section stops cooling. This happens when compressor oil rises into the evaporator coil — blocking the capillary tube and reducing cooling.
Here is how we fix it —
✅ Release old gas completely
✅ Flush the coil with special cleaning solution (works like a medicine — removes all oil buildup)
✅ Clean and clear the capillary tube — so gas flows freely again
✅ Check and clear the filter drier if blocked
✅ Refill with fresh gas after cleaning
After this process, your normal section cools properly again.
Why choose our Fridge Repair Service in Demra,Dhaka
A family near Shyampur in Demra had a 2-ton Hitachi two-door fridge where both sections had stopped cooling but the compressor was still attempting to start — making a humming sound followed by a click and then stopping. This specific pattern — hum, then click off — is the definitive sign of a failing compressor that can no longer start under normal conditions. However, our technician's assessment at their Shyampur building revealed that the starting capacitor had failed — the compressor was intact but could not start without its capacitor providing the additional torque to begin rotation. The capacitor was replaced and the compressor started cleanly — both fridge sections returned to temperature within 2 hours. Mr. Faruk gave us a five-star review and mentioned he had been quoted ৳8,000 for compressor replacement by another technician without any diagnosis — our ৳1,200 capacitor replacement had restored the fridge completely. We repair fridges throughout Demra and Shyampur with honest diagnosis before any replacement recommendation.
Our Other Services
◉ AC Basic Wash ◉ AC Foam Wash ◉ AC Jet Wash
◉ Car wash ◉ Car polish
Pricing
⚠️ Final price confirmed after inspection. Prices may vary depending on fridge size and condition.